Product ID:A-4100-SERIES AEROSOL ENAMEL, A-4100
MSDS Date:05/10/1991
FSC:8010
NIIN:00N028691
MSDS Number: CBVVD

CARDINAL INDUSTRIAL FINISHES

1329 POTRERO AVE
SO EL MONTE, CA 91733
US

Emergency Phone: 818-444-9274

Info Phone: 818-444-9274

Preparer: RICHARD STEWART

Cage: 65860

CARDINAL INDUSTRIAL FINISHES

SOUTH EL MONTE, CA 91733 US

Telephone: 818-444-9274 OR 213-283-9335

Cage: 65860

9.0 @ 68F.

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 2%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM; 150 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

TOLUENE (SARA 313) (CERCLA). 22.0 @ 68F.

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 10%

OSHA PEL 200 PPM; Z-2

ACGIH TLV: 50 PPM, S

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ACETIC ACID, ISOBUTYL ESTER; (ISOBUTYL ACETATE) (CERCLA).

CAS: 110-19-0

RTECS: AI4025000

Fraction By Weight: 5.0%

OSHA PEL 150 PPM

ACGIH TLV: 150 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2.0 @ 68F.

CAS: 8032-32-4

RTECS: OI6180000

Fraction By Weight: <5.0%

OSHA PEL 300 PPM

ACGIH TLV: 300 PPM

TITANIUM OXIDE;(TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: <5.0%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

ACETONE (SARA 313) (CERCLA). 196.0 @ 68F.

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 24%

OSHA PEL 1000 PPM

ACGIH TLV: 750 PPM; 1000 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

8.6 @ 68F.

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 50%

OSHA PEL 1000 PPM

ACGIH TLV: ASPHYXIANT

5.39 LB/GL (645 G/L).

RTECS: 9999999VO

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:SEV EYE IRRIT, BLURRED VISION.
CAN CAUSE MOD SKIN IRRIT, DEFAT OF TISS, DERM. INHAL: HDCH, FATG,
WEARINESS, NAUS, VOMIT, DIZZ, STUPER, DROW, DISTURB VISION, COUGH &
UNCON. SKIN: PRLNGD CONT CAN CAUSE MOD IRRIT, DEFAT & DERM. EYE:
CANCAUSE SEV IRRIT, REDNESS, TEARING & BLURRED VISION. (EFTS OF
OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:SKIN(ABSORP): MOD IRRIT, DEFATTING,
DERM, DRY SKIN & RASH. INGEST: BREATH SMELLS OF SOLV, IRRIT OF LIPS
& MOUTH, GI IRRIT, NAUS, DIARR, DROW, LOSS OF CONC, STATE OF SHOCK,
WEAK & RAPID PULSE, COLD-PALE COMPLEXION. CHRONIC: MAY PRDCE LIVER
& KIDNEY DMG, PERSIST COUGHING, BRAIN DMG, MAY EVEN CAUSE
DEATH.(SUPDAT)
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY
CONDITIONS, PRE-EXISTING SKIN DISORDERS, LIVER & KIDNEY DISORDERS.

First Aid:EYE: FLUSH W/PLENTY OF WATER FOR AT LEAST 15-30 MINS. GET MED
ATTN. SKIN: WASH EXPOSED AREA W/MILD SOAP & WATER FOR AT LEAST 15
MINS. REMOVE CONTAMD CLTHG. INHAL: REMOVE TO FRESH AIR. IF
BREATHING IS DFCLT, ADMIN OXYGEN. IF BRTHG HAS STOPPED, GIVE ARTF
RESP. GET MED ATTN. INGEST: DO NOT INDUCE VOMITING. KEEP VICTIM
WARM & SEEK MED ATTN.

Flash Point Method:TCC
Flash Point:-154F,-103C
Lower Limits:0.7%
Upper Limits:12.8%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT. BEWARE OF EXPLOSIONS.
Unusual Fire/Explosion Hazard:HEAT WILL CAUSE EXPLOS OF AEROSOL CNTNR
DUE TO INCREASED PRESS. PROPANE IS EXPLOS WHEN EXPOSED TO FLAME.
ISOLATE FROM HEAT, SPARKS, ELEC EQUIP & OPEN FLAME.

Spill Release Procedures:FOLLOW INSTRUCTIONS TO PVNT HLTH HAZS. ELIM
ALL SOURCES OF IGNITION, ABSORB LIQUIDS IN ABSORBANT MATL & PVNT
SPREADING TO GROUND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:CNTNRS MAY BE HAZ WHEN EMPTIED, SINCE
EMPTIED CNTNRS MAY RETAIN PROD RESIDUALS (VAPS, LIQS, &/SOLIDS),
ALL PRECS GIVEN IN THIS MSDS MUST BE OBSERVED.
Other Precautions:STORE AT ROOM TEMPERATURES AWAY FROM HEAT SOURCES AND
HAVE LIDS TIGHTLY CLOSED. PROPANE - MAY BE NARCOTIC IN VERY HIGH
CONCS.

Respiratory Protection:IF TLV OF PROD/ANY COMPONENT IS EXCEEDED,
NIOSH/MSHA JOINTLY APPRVD AIR SUPPLIED RESP IS ADVISED IN ABSENCE
OF ENVIRON CONTROLS. OSHA REGS ALSO PERMIT OTHER NIOSH/MSHA RESPS
UNDER SPEC CNDTNS. (SEE SA FETY EQUIP SUPPLIER)ENGINEERING(SUPDAT)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL &/LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW THE TLV'S.
Protective Gloves:PVA COATED/POLYETHYLENE GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA. HANDCREAM, IMPERVIOUS CLTHG & CHEM RESIST
BOOTS.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING REST ROOM,
SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
RESP PROT: OR ADMIN CONTROLS SHOULD BE IMPLEMENTED TO REDUCE EXPOSURE.
EFTS OF OVEREXP: NOTE: TOLUENE APPEARS ON THE NAVY LISTING OF OCCUP
CHEMICAL REPRODUCTIVE HAZARDS. SEEK CONSULTATION FROM APPROPR IATE
HEALTH PROFESSIONALS CONCERNING LATEST HAZARD LIST INFORMATION AND
SAFE HANDLING AND EXPOSURE INFO.

Boiling Pt:B.P. Text:>-44F,>-42C
Vapor Pres:SEE INGS
Vapor Density:LTR/AIR
Spec Gravity:0.7(H*20=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NON SOLUBLE
Appearance and Odor:VARIOUS COLORS W/SOLVENT ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:TEMPERATURES ABOVE 120F.
Hazardous Decomposition Products:HAZARDOUS DECOMPOSITION MAY PRODUCE
CARBON MONOXIDE AND/OR CARBON DIOXIDE.

Waste Disposal Methods:"DO NOT INCINERATE." DISPOSE OF IN ACCORDANCE
W/LOCAL, STATE & FEDERAL REGULATIONS. AVOID PUNCTURE OF CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.